CRM Mitchell1, Author at Chicago Driveline Inc

2011 Chevrolet Equinox
Mileage
123,764
Service Date
10/23/2023
Services Performed
Road tested vehicle and scanned for codes. Found P0089- fuel pressure regulator performance, and P0191- fuel rail pressure sensor performance. These codes point to a possible high pressure fuel pump issue. After observing data on scan tool while operating vehicle found a difference between desired and actual fuel rail pressure, indicating a high pressure fuel pump issue. Also found the HP fuel pump making excess noise with engine running. Customer advised us the HP fuel pump was replaced elsewhere within the last 6 months. Recommend returning to service center that previously replaced the pump for further evaluation.
Found noise from HP fuel pump. Recommend removal and inspection of pump and camshaft surface which drives the pump.
Mike / Theresa B. gave our service a 5 star review on 10/23/2023
2013 Ford F-150
Mileage
190,755
Service Date
10/19/2023
Services Performed
Test drove vehicle multiple times and was unable to duplicate customer concern. Inspected vehicle on hoist and after speaking with customer removed LF axle and inspected 4wd actuator and found minor metallic particles between wheel bearing, actuator, and axle. Found evidence of grinding on actuator itself, and very minor wear on wheel bearing teeth. Cleaned off remaining metallic particles, and filed away minor wear in wheel bearing teeth. Recommend replacing 4wd actuator, and rechecking vehicle operation.
L/F INTEGRATED WHEEL END (IWE) – Remove & Replace – IWE,One Side
Alan C. gave our service a 5 star review on 10/19/2023
2011 Chrysler 300
Mileage
96,705
Service Date
10/17/2023
Services Performed
TEST DROVE VEHICLE 2X AND COULD NOT DUPLICATE CUSTOMER CONCERN…RAISE VEHICLE AND INSPECT TIRES AND FRONT SUSPENSION TO FIND ALL GOOD….TIRES WERE MISMATCHED…TWO DIFFERENT BRANDS. MATCHED FRONT TIRE BRANDS AND BALANCE…TEST DROVE AGAIN AND CAR SEEMS FINE.JW. ALL FRONT END PARTS AND SUSPENSION IN GOOD CONDITION AT THIS TIME.
Inspected vehicle on hoist and scanned for codes. Found multiple EVAP system related codes including P0443- evap purge control circuit, P0456- evap system small leak, P0455- evap system large leak, and P0440- general evap system failure. After performing system diag found faulty purge valve, eism switch, and capless filler neck. After parts replacement, cleared codes, and performed evap system self test, and found vehicle now passed. Vehicle will still have to be driven for a period of time for the small leak self test monitor to run and clear.
INSTALL CANISTER PURGE VALVE
FUEL TANK FILLER PIPE – Remove & Replace
NATURAL VACUUM LEAK DETECTION PUMP – Remove & Replace – ESIM Switch,Natural Vacuum Leak Detection Module
Jim G. gave our service a 5 star review on 10/17/2023
2005 Jeep Grand Cherokee
Mileage
192,060
Service Date
10/12/2023
Services Performed
CK THUMPING NOISE WHEN PUTTING INTO GEARLIKE BAD MOTO MOUNT , ALSO HUMMING IN FLOOR BOARDS AT 30MPH
AXLE ASSEMBLY – Remove & Replace, Both Front CV Axles
AXLE HOUSING BUSHING – Remove & Replace – Pinion Housing
Ron K. gave our service a 5 star review on 10/12/2023
2007 Ford Expedition
Mileage
193,098
Service Date
10/10/2023
Services Performed
CK ENGINE LIGHT ON BOGS WHEN GAS IS FULL, RUNS FINE AFTER FUEL IS RAN LOWER THAN FULL. CUSTOMER BEEN THROWING PARTS AT THIS.
CANISTER PURGE SOLENOID & FUEL CAP- Remove & Replace –
Cathy B. gave our service a 5 star review on 10/10/2023
2017 Ford F-450 Super Duty
Mileage
32,086
Service Date
10/4/2023
Services Performed
Changed Motor Oil & Replaced Filter, Added 5 QTS Synthetic Motor Oil, Lube Chassis, Check all Fluid Levels
INSTALL AIR FILTER
INSTALL BATTERY
Jim B. gave our service a 5 star review on 10/4/2023
2005 GMC Savana
Mileage
191,070
Service Date
10/4/2023
Services Performed
TOW SERVICE B/R INV# 104678
Inspected vehicle on hoist and found LF wheel bearing heavily damaged. Found minor play in RF bearing. Also during inspection found both front outer ties rods had play, RF being the worst. Recommend replacing both front wheel bearings, along with.both outer tie rod ends, and performing wheel alignment.
FOUND EXCESSIVE MOVEMENT AND ABOUT TO FALL APART SAFETY ISSUE/CONCERN
EXCESSIVE MOVEMENT AFTER DIAG.
TWO Wheel Alignment. Warranty-30 Days
Changed Motor Oil & Replaced Filter, Added 5 QTS Blended Motor Oil, Lube Chassis, Check all Fluid Levels
James / Damone R. gave our service a 5 star review on 10/4/2023
2007 Ford Pickup
Mileage
99,249
Service Date
10/3/2023
Services Performed
CK DRIVESHAFT RUBBING ON SOMETHIMG
PROPELLER SHAFT – Removal & Installation – RWD Rear,Two Piece Driveline
install center bear to shaft
Glen G. gave our service a 5 star review on 10/3/2023
2010 Chevrolet Malibu
Mileage
53,187
Service Date
10/3/2023
Services Performed
Changed Motor Oil & Replaced Filter, Added 5 QTS Blended Motor Oil, Lube Chassis, Check all Fluid Levels
Beverly M. gave our service a 5 star review on 10/3/2023
2016 Jeep Grand Cherokee
Mileage
29,237
Service Date
9/28/2023
Services Performed
Changed Motor Oil & Replaced Filter, Added 5 QTS Synthetic Motor Oil, Lube Chassis, Check all Fluid Levels
Mount and balance four tire/wheel assemblies.
Tire disposal fee
Tire user fee
Kevin V. gave our service a 5 star review on 9/28/2023

CRM Mitchell1

We Service and Repair all CRM Mitchell1 cars